2002 Ford Explorer Lugs/Nuts/Bolts Problems
- 10
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
What owners report
- wheel studs · 4 records
- steering wheel · 4 records
Mileage in stored records
| Band | Records |
|---|---|
| 60–100k mi | 3 |
| 1–30k mi | 1 |
| 100–150k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Lugs/Nuts/Bolts
Tl* the contact owns a 2002 ford explorer. While driving approximately 10 mph, the contact noticed that the rear passenger side tire rode roughly. The contact noticed that three of the wheel studs were sheared off. The failure occurred four times with the remaining wheel studs. The vehicle was not diagnosed or repaired. The manufacturer was notified. The approximate failure mileage was 140,000. Updated 10/02/14*lj…
ODI 10621374
Coil Springs · Lugs/Nuts/Bolts
2002 ford explorer. Consumer states problem with tires *tgw the consumer experienced a tire blow on the right rear tire. When triple aaa arrived, the consumer was informed the rear coil spring along with 3 lug nuts had failed. In july 2010, three more lug nuts broke again. *jb
ODI 10370005
Lugs/Nuts/Bolts
Tl*- the contact owns a 2002 ford explorer. While driving 65 mph, the vehicle started vibrating and pulling to the right. A lug nut hit the windshield and the vehicle came to a sudden stop because the front passenger side tire was lodged underneath the vehicle. The vehicle was towed to the dealer to replace the new lug nut and stems and repair the damage to the vehicle. The failure mileage was 71,000. The current…
ODI 10181751
Lugs/Nuts/Bolts
Dt*: the contact stated while driving 15mph the right rear wheel wobbled. The vehicle was taken to an independent repair shop for inspection. The mechanic determined that the lug nuts were broken which resulted in the loose rear wheel. The mechanic replaced the broken lug nuts.
ODI 10152176
Lugs/Nuts/Bolts
I was driving down county road branch, it felt like i was driving on a bumpy road (what it feels like when your tire goes flat) i turned on lateral b south, then it got worse, so i stopped and checked all tires, they were all okay, then i start driving 20 feet further then i stopped again, my oldest son took of the hub and discovered 3 out of 5 bolts with lug nuts were broke off in the right rear passenger hub. *nm
ODI 10095627
Lugs/Nuts/Bolts
I had 1 wheel stud break and ordered a replacement from dealer. Wheel studs only come in packs of 5. Wheel stud replaced and about 4 months later 2 more broke simultaneously.
ODI 10096146
Lugs/Nuts/Bolts
Driver rear tire separated from vehicle.*mr the failure was the result of the lug nut breaking. The vehicle sustained a dent hub cap, and light damage to the left rear bumper and panel. *ph *jb
ODI 10040657
Constant Velocity Joint · Lugs/Nuts/Bolts
Noted "clicking" noise when wheel turned at slow speed, assumed cv joints were going bad. However, dealer said that lug nuts were loose, and when tightened the noise stopped. What is notable is that the wheels have never been off, so this condition originated at the factory. Dealer says owner at fault and charged for the repairs. Owner says this a factory defect and a significant safety item and insist it be covered…
ODI 10025282
Lugs/Nuts/Bolts
On 8-10-01 i was driving a hertz car rental 2001 0r 2002 ford explorer on i-75 to the atlanta airport. I began noticing "shimming" in the steering wheel. Soon after the "shimmying " became worse and i experienced excessive "play" in the steering wheel. I pulled onto the shoulder without incident. Later, a tow truck driver discovered that 3 out of 5 lug nuts had been sheared off completely - - causing the right front…
ODI 750247
Lugs/Nuts/Bolts
On 8-10-01 i was driving a hertz car rental 2001 0r 2002 ford explorer on i-75 to the atlanta airport. I began noticing "shimming" in the steering wheel. Soon after the "shimmying " became worse and i experienced excessive "play" in the steering wheel. I pulled onto the shoulder without incident. Later, a tow truck driver discovered that 3 out of 5 lug nuts had been sheared off completely - - causing the right front…
ODI 750246