2004 Ford Explorer Lugs/Nuts/Bolts Problems
- 7
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Mileage in stored records
| Band | Records |
|---|---|
| 30–60k mi | 3 |
| 60–100k mi | 3 |
| 100–150k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Lugs/Nuts/Bolts · Rim
Tl* the contact owns a 2004 ford explorer. While driving approximately 20 mph, a rattling sound emitted from the vehicle. After parking and inspecting the vehicle, the contact discovered that four lug nuts were detached from the rear passenger tire and two of the rim spokes were cracked. The vehicle was taken to an independent mechanic. The technician was unable to diagnose the failure. The vehicle was repaired. The…
ODI 10663329
Lugs/Nuts/Bolts
Tl* the contact owns a 2004 ford explorer. While driving at an unknown speed, the vehicle shook and vibrated. The failure occurred twice. An independent mechanic replaced the studs on both front wheels. The manufacturer was notified of the failure. The approximate failure mileage was 119,884.
ODI 10632706
Lugs/Nuts/Bolts
Tl* the contact owns a 2004 ford explorer. The contact was driving less than 10 mph and approaching an intersection to attempt a left turn. Suddenly, the front end of the vehicle collapsed and the front passenger wheel fractured from the vehicle. The vehicle was towed to an authorized dealer yet the technician was unable to locate the problem. The manufacturer referred the contact to an independent mechanic for…
ODI 10352346
Lugs/Nuts/Bolts
Tl*the driver owns a 2004 ford explorer. The driver stated that four of the studs on the right rear rotor broke off and that the wheel almost fell off. He heard a loud noise while driving approximately 25 mph. The vehicle was towed to a repair shop. A local mechanic informed him that the studs broke and replaced all five studs. The contact neither took the vehicle to the dealership nor spoke with the manufacturer…
ODI 10305779
Lugs/Nuts/Bolts
Tl*the contact owns a 2004 ford explorer which was purchased in september 2007. While driving 25 mph and making a right turn, the rear driver's side wheel came off of the vehicle. The vehicle hit the ground and would not move any further. The lug nuts and bolts sheared off of the wheel assembly. The vehicle was towed to a local service center where they replaced the lug nuts and bolts. On a separate occasion, while…
ODI 10300284
Lugs/Nuts/Bolts
Right-rear wheel fell off while traveling 40 mph. Fortunately nobody was hurt this time. After reading other posts about problems with wheels falling off and with lug:nuts i decided to post our incident too. *ak
ODI 10187009
Lugs/Nuts/Bolts
Without warning the rear wheel of my 2004 ford, explorer broke off going 65 on the interstate. All five lugs snapped off. No one took responsibility. I had to pay for repairs. It was either a defect or negligence on the part of the dealer where i had it serviced. *nm
ODI 10183514