2015 Ford Explorer Engine Problems
- 142
- Owner complaint records in our dataset
Records are owner complaints, not a measured failure rate.
Owner complaint recordsComplaint records reflect reports in our dataset and do not measure how frequently the problem occurs across all vehicles.
Among these 142 stored complaint records:
- 0 indicate a crash
- 5 indicate injury
- 0 indicate fire
What owners report
- carbon monoxide · 26 records
- exhaust fumes · 22 records
- exhaust smell · 13 records
- exhaust odor · 12 records
- failure mileage · 8 records
- failure recurred · 8 records
Mileage in stored records
| Band | Records |
|---|---|
| 1–30k mi | 76 |
| 30–60k mi | 39 |
| 60–100k mi | 12 |
| 100–150k mi | 1 |
Complaint records
Owner-submitted complaint content, presented as stored.
Engine
In december 2019 while driving at about 70 mph uphill on interstate highway at nightime, the engine suddenly lost power. Depressing the accelerator pedel had no effect and the transmission acted as if it was shifted to neutral even though it was still in drive. The engine rpm seemed to dropp to idle speed. I lost forward motion rapidly. I had to cross two lanes of high speed traffic to pull onto shoulder. It was a…
ODI 11297954
Engine · Exterior Lighting · Unknown Or Other
It's popping up low engine power and it will shut down everything from lights to blind spot detection. It just started doing this after running through a small water puddle.
ODI 11271190
Engine · Seats
Ford explorer 3.5l ecoboost engine timing chain stretch @ 61,902 miles... $2500 repair bill on a very well maintained and preventative maintenance schedule minded owner. Also, at 42k miles the lumbar bag on drivers seat deflated and won't inflate...
ODI 11271227
Engine
STRONG ODOR OF EXHAUST IN CABIN OF VEHICLE
ODI 11266974
Engine
On my 2015 ford explorer xlt, the water pump which is encased inside the cyclone/duratec engine, broke and leaked coolant which was mixed with the oil, tge oil pan and the oil pump causing complete engine failure. There was no advance warning and ford has not issued a recall although a number of models have been affected. This caused me to have to replace my engine at my expense. Ford motor company has not taken any…
ODI 11291510
Engine
Beginning in 2007 and continuing through the present, ford has equipped millions of vehicles sold under the ford, lincoln and mercury brand names with the ford cyclone engine, also known as the duratec engine. Unbeknownst to purchasers and lessees of these vehicles, the ford cyclone engine contains a defect in design, manufacturing, materials and/or workmanship that causes the water pump to suddenly and prematurely…
ODI 11280649
Engine
The police interceptor utility was being driven with windows down in a parking lot when a foul odor was smelled by the officer, followed by the carbon monoxide alarm activating. The reading on the co alarm was 127 ppm. The vehicle was taken to hilltop ford and a repair was made to the egr purge valve. The vehicle was returned to service and within a couple of days the co alarm activated again, however no smell…
ODI 11270669
Engine
Both exhaust manifolds were cracked. Removed and drilled out broken studs and installed new converters. I heard a noise for a day or two and brought it in and they said this was the issue. I maintain my vehicle regularly at the ford dealer and never indicated a problem. They said no recall but i googled it and i see many complaints with the same issue for my year, make and model.
ODI 11251868
Engine
Wastegate issues. Decrease in power and acceleration causing safety hazards while driving. Pulled onto a highway while in traffic (65mph) and i couldn't accelerate as needed when pulling onto a highway and was nearly rear ended.
ODI 11246254
Engine
Vehicle has strong exhaust like burnt hair under harder acceleration. For instances, climbing a hill and needed to speed up. The smell stays with the vehicle as well. For at least a mile after the fact. I have had several vehicles and never have i had one smell like that under acceleration.
ODI 11222313
Engine · Fuel/Propulsion System · Unknown Or Other
On 6/6/19 vehicle lost engine throttle power when "wrench" light indicator appeared on dashboard while driving on interstate (at least 65mph). Wrench noted terrain management system error. Engine did not shut off. Vibrated very badly when coming to stop. Happened again on 6/[redacted] driving approx 35mph. Both times stopped vehicle, turned off, and restarted and operated normally. Ford dealerships cannot determine…
ODI 11219435
Engine · Steering · Suspension
A little over a month ago the left rear toe link broke while driving. This caused the car to lose control and go into a sideways slide, breaking the wheel hub in the process. Smooth road going about 50 mph in good conditions. We got the car fixed and had to pay for the repairs since the car is no longer under factory warranty. After the ford dealer in mchenry il had it for over a week, we got the car back, drove it…
ODI 11234314
Engine · Steering
While driving recently my car would 'sputter' while at a light etc. Well today it completely dies while driving (about 20mpg). It eventually restarted and i was able to drive to my mechanic. The vehicle completely died while pulling into the drive of the mechanic who will take a look on monday. Also, had problems with steering unit that ford said needed to be replaced. Said that would cost us about $1100 for a new…
ODI 11217196
Body · Engine
The side panel popped out in the front passenger side of the vehicle for no apparent reason. The ford dealership i took it to was aware of it. The second issue we had at 66,000 miles was an error called 'terrain management fault'. Both times this error occurred, we were moving. The first time it happened it fixed itself. The second time, we had to have it towed. This is so dangerous and someone is going to get hurt…
ODI 11217200
Engine
When accelerating in my vehicle from a stopped position and when driving on the expressway, there is a carbon monoxide odor and i get light headed and have headaches afterward. This has continued after my vehicle was repaired by a ford dealership due to the recall. This has happened several times before and after the repair.
ODI 11196728
Engine
Check engine light came on. Took the car to conrad's. Scanned code and the result is engine timing chain needs to be replaced and possibly the engine. Have quotes from multiple service stations and each one said this engine has lots of problems.
ODI 11203335
Engine · Vehicle Speed Control
Tl* the contact owns a 2015 ford explorer. While driving 40 mph, the vehicle stalled and the check engine indicator illuminated. The vehicle was taken to an independent mechanic, but the cause of the failure could not be determined. However, the mechanic stated that the throttle body needed to be replaced. Haldeman ford (640 us-130, east windsor, nj 08520, [redacted]) was contacted and stated that the vehicle was…
ODI 11245434
Engine
2015 ford explorer limited approximately 80000 miles. While in motion loses engine all engine power and begins to shudder. The vehicle will not accelerate at all. After stopping the vehicle, shifting into park, shutting the engine off and restarting, the problem goes away as if it never happened. When this occurs the dashboard indicates 'service terrain system management' with the wrench icon. It has happened…
ODI 11186917
Electrical System · Engine
Water pump started leaking at 54000 miles right out of warranty. Was told needed replacement or else engine would seize. Paid over $2,100 to get it replaced. Stupid design and hard labor to get to it. Car has vibration now ever since we had it repaired but thought it was normal leaving dealer. I don't know why this hasn't been recalled. Now, the parking aid went out. These cars are horrendous
ODI 11191734
Engine
Exhaust leaking into cabin. Filling cabin of vehicle with a sulfer or cat pee smell.
ODI 11171253
Engine · Power Train · Unknown Or Other
Exhaust smell coming through cabin when idling and in motion. With ac/heat on and off. Most significantly when accelerating. It has caused me to have major headaches and nausea. It has went to the dealership to be 'fixed' but problem is still occurring.
ODI 11181732
Engine
When accelerating, smell fumes and onset of dizziness and blurred vision while driving. Immediately slowed down (almost to a stop) in mid traffic and opened windows, allowing fresh air to blow in. Dizziness went away after a minute or two. Happened twice...very scary experience. Carbon monoxide poisoning? Never experience this before nor outside of vehicle. Already had exhaust problem fix by dealer...still having…
ODI 11162310
Engine
After just 63,000 miles both turbos on my 2015 ford explorer sport failed. One was confirmed as leaking oil which could result in an engine fire. Additionally, it was confirmed that the vehicle's timing cover was leaking, also at risk for engine fire. Vehicle has been immaculately maintained with all scheduled service and timely synthetic oil changes.
ODI 11152098
Engine · Fuel/Propulsion System · Power Train
Loss of power: while driving my 2015 ford explorer xlt with 3.5l v-6 engine on the highway (10/04/18), the wrench light came on and the car started to shudder and lose speed. Pushing down on the accelerator had no affect and the car rapidly decelerated. The engine was running very rough with heavy vibration. This was a terrifying and nearly fatal experience as faster moving traffic started passing me on both sides…
ODI 11139061
Engine · Steering
This complain is for ford explorer sport 2015 that i own and has 26,000miles. I bought this car brand new from the dealer and i've been having a problem with steering wheel. Every time when i get out from the parking or trying to park the car,i turn the steering wheel left and right and i get this squeezing noise. Beside this problem, the engine makes a whistle noise when is parked. I had this whistle noise 4months…
ODI 11155499